Tankless Water Heater Sediment Trap

The existing line is 1 2 inch pipe that extends horizontally about 2 inches into the closet with a shut off valve attached and then a 24 inch flex tubing.

Tankless water heater sediment trap.

This filter system provides the ultimate protection for your tankless water heater. Make sure you have the purge and drain valves on hand since they do not come with many water heaters. The 199 900 btu natural gas tankless water heater is designed to supply continuous hot water for up to 3 bathrooms at the same time. Manufacturer s recommendations shall be followed.

Compatible with all tankless water heater models. Sediment trap for a tankless water heater. You must also have another trap or other means of attaching a manometer immediately on the downstream side. Sediment traps are used to well trap sediment from gas lines.

Keep your tankless water heater operating in top performance and efficiency by installing a sediment filter kit ideal for tankless water heaters. Therefore the gas appliance does not have any sediment entering the gas chamber. Aiming the gas flow straight down pushes anything caught in the gas line into the trap where it cannot enter the appliance gas chamber. According to both the nat l and int l fuel gas codes you must have an approved shutoff immediately upstream of a medium pressure regulator and a sediment trap.

Instructions for installing the new water heater say the incoming gas line should have a sediment trap. A simple and effective way to protect your tankless water heater from the harmful affects of sediment is to use a pre filter that will remove the debris before it enters the unit. Sediment traps sometimes mistakenly referred to as drip legs are designed to catch sediment in natural gas before it enters into the water heater or furnace gas valve. This filter will capture and trap any debris or particles that would otherwise interfere with the operation of your tankless water heater.

Different areas have different contaminants in the gas and the traps help catch these. Attach the gas supply line to the shutoff valve. The rheem eco200xln3 1 outdoor natural gas tankless water the rheem eco200xln3 1 outdoor natural gas tankless water heater can provide up to 9 5 gpm at a 35 temperature rise. A sediment trap is required per cpc section 1212 9.

I plan to replace the flex tube but is a sediment trap really needed. When replacing a storage tank water heater with a tankless water heater the gas line connected to the water heater and the pipe size of each section to the water heater shall be sized to meet the increased btu demand rating. These are pipe extensions that aim gas flow straight down.