Solar Water Heater Maintenance Checklist

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for.

Solar water heater maintenance checklist.

1 temperature of hot water. Turn off the heat. When calling for assistance please have the following. Open t p relief valve to relieve pressure.

Let the water run until it stops flowing. Drain 2 3 gallons of water. Whether the tank is gas or electric turn off its heating source the night before. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater.

Install pump onto the water heater discharge using pipe fitting. Turn off cold water supply and open drain valve. Check to make sure the water to the hot water heater has been completely shut off. Be sure to check the water draining out and make sure it is clear.

Don t miss the temperature and pressure valves. Satisfactory not satisfactory 2 quantity of hot water supply. Drain the water from the hot water pipe. Disconnect the hot water heater at the hot water discharge.

Also read your owner s manual. Two major factors affecting the performance of properly sited and installed solar. Allow a few gallons worth of water to drain. Regularly scheduled maintenance should include.

Open a hot water. Here are some suggested inspections of solar system components. Preventing scaling and corrosion. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out.

If water is milky drain entire tank. Use a solution of dish soap and warm. Satisfactory not satisfactory 3 constant temperature e g. The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel.

Solar water heating system maintenance and repair periodic inspection list. If that is too. Close drain valve and open cold water supply valve. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector.

Solar hot water heaters are no different except that because they have more components there is more that can go wrong.